Subaru Valve Shims Docs

  • document

    Subaru Valve Spring Compressor Manual

    1 512 - Subaru Valve Spring Compressor Tool Instructions SPECIAL NOTES: • The use of a factory service manual is highly recommended. These can be purchased at the dealer, or

  • document

    2.5 Liter Twin Cam Adjustment

    each cam lobe is facing 180 degrees away from the adjustment shim, Subaru has very specific procedures for adjusting four valves at a time (a pair of intakes and ... valve shims. For intake valves: S = (V + T) - 0.20 mm For exhaust valves: S = (V + T) - 0.25 mm S equals the new shim thickness

  • document

    Tame Ticking Tappets: VALVE - MOTOR

    VALVE ADJUSTMENT TECHNIQUES Think valve adjustments are strictly a historical curiosity? ... Engines with valve adjustment shims require special tools and techniques. ... from a Subaru, depicts manifold absolute pressure. Consequently, ...

  • document

    SUBARU EJ20 / EJ25 WRX / STi Turbo DOHC INTAKE VALVE EXHAUST ...

    CF-35/2.7+ or CF-35/3.7+ (+ Shims 1.5mm to 3.2mm thick) / RET-TS60/STI available for Under the Bucket Shim (JDM) I.D. (mm) INTAKE: VS-TS6I 20,00 Outer Spring ... INTAKE VALVE Head Diam SUBARU EG33 H6 24v Head Diam 21,90 EXHAUST VALVE 32mm(std) 5.96mm. Title: subaru

  • document

    BRAKE SYSTEM - SECCS

    BRAKE SYSTEM 1992 Subaru SVX 1992 BRAKES Subaru Disc & Drum Justy, Legacy, ... Inspect brake vacuum check valve for proper operation. If check valve is okay, replace power ... noting positions of pad clips and shims. 2) Minimum pad thickness, including metal backing plate, is .

  • document

    A/C COMPRESSOR SERVICING - SECCS

    A/C COMPRESSOR SERVICING 1992 Subaru SVX 1992 AIR CONDITIONING & HEAT Compressor Servicing ... rear valve plates, reed valves, and "O" rings. 3) To install, ... add or remove shims as necessary. FORD FX-15 SHAFT SEAL R & I Removal 1) ...

  • document

    insider info. - Subaru Forester.org

    Several Subaru engines use shims to adjust valve clearance. If you don’t have a micrometer, acquire one that is calibrated in millime-ters. Even though the service interval for adjusting the valves is 100,000 miles, there are 16 of

  • document

    BRAKE SYSTEM - Home - Numbchux Conversions

    1996 Subaru Impreza 1995-96 BRAKES Subaru - Disc & Drum Impreza, Legacy ... a gravity-actuated Pressure Hold Valve (PHV) to control fluid flow to ... Install anti-squeak shims on both inner and outer pads. Install pad clips to support bracket and install pads. Rotate caliper body down, ...

  • document

    4. Cylinder Head

    2. VALVE SEAT Inspect intake and exhaust valve seats, and cor-rect the contact surfaces with valve seat cutter if they are defective or when valve guides are

  • document

    Subaru is a division of Fuji Heavy Industries Ltd ...

    Subaru is a division of Fuji Heavy Industries Ltd., headquartered in Tokyo, Japan. ... • 13.5 hp overhead valve Subaru engine with low oil shut-off system • Quick clean out, easy-open cover ... replaceable shims offer maximum performance over the life of the pump.

  • document

    4. Cylinder Head - Subaru Outback.org

    B2M1221A 1) Remove shims and valve lifters. 2) Compress the valve spring and remove the valve spring retainer key. Remove each valve and valve spring.

  • document

    OE ENG VALVES - MOTOR

    sive valve clearance noises with a me- ... from Honda and Subaru, slow-crank the engine until the appropriate valve is ... makes there are shims, and if it’s nec-essary to adjust clearance, you’ve got to replace them. You’ll need a special tool kit to depress the lifter so the shim can be ...

  • document

    MECHANICAL 17.Crankshaft Sprocket B: INSTALLATION

    (Without installing the valve rocker.) (3) Place a plastigauge across each of the cam-shaft journals. (4) ... Remove the valve shims and valve lifters. 2) Compress the valve spring and remove the valve spring retainer key. Remove each valve and

  • document

    www.weidefamily.net

    ... .com Pilot Bearing 806212020 1 $7.26 $7.26 1stsubaruparts.com Oil Pump O-ring 806919050 1 $2.58 $2.58 Dealer Valve Shims Assorted 6 $5.10 $30.60 Dealer Clutch Fork Boot 30542AA000 1 $19.12 $19.12 ... Exhaust Manifold Stud 800910550 $1.10 Cometic Head Gasket Subaru Legacy ...

  • document

    Semi-Trash > Print chart 2IN / PKX201ST

    Subaru Robin Semi-Trash > Print chart 2IN / PKX201ST Performance Curve: Pump Overview: ... Shimmable Impeller to Volute Shims allow the clearance to be readjusted between the impeller and volute as the ... Fuel Shut Off Valve with

  • document

    Trash > Print chart 2IN / PKX201T - Continental Pumps

    Subaru Robin Trash > Print chart 2IN / PKX201T Performance Curve: Pump Overview: ... Shimmable Impeller to Volute Shims allow the clearance to be readjusted between the impeller and volute as the ... Fuel Shut Off Valve with

  • document

    2004 IMPREZA SERVICE MANUAL QUICK REFERENCE INDEX ...

    SUBARU genuine parts. All information, illustration and specifi- ... Control Valve Body ... Select three or less shims from following table. E: INSPECTION • Make sure that all component parts are free of harmful cuts, gouges, ...

  • document

    FRONT MOUNT INTERCOOLER 2008+STI - PERRIN Performance

    FRONT MOUNT INTERCOOLER 2008+STI 083111 ... If SS shims are found between bumper beam and IC, make sure to reuse them. ... connect valve cover vent hoses from both left and right valve cover vents to tee, and connect inlet hose connection to the leftover spigot on tee.

  • document

    2004 IMPREZA SERVICE MANUAL QUICK REFERENCE INDEX ...

    of SUBARU vehicles. This manual includes the procedures for maintenance, disassembling, ... Control Valve Body ... up to four adjusting shims from the table, suitable for clearance value. When clearances are 0.05 mm ...

  • document

    PT 2 / PT 3 / - Wacker Neuson

    contact Wacker Corporation to order a replacement. ... 4.15 Valve Clearances (Hatz) ... 5.6.6 Place 6–10 shims (f) between the shim plate (e) and the volute, and secure them to the volute with three screws (d).

  • document

    AUTOMOTIVE

    AUTOMOTIVE. NOTES NEBRASKA-IOWA INDUSTRIAL FASTENER CORP. Rev. 9/99 XI-a AUTOMOTIVE ... SHIMS Alignment 33, 34 Body 33, 34 SNAPS 44 SPRINGS Carburetor Return 1 Universal 1 STUD ... Subaru 15540 18 x 1.5 Toyota, Renault 15536 12 x 1.75 GM 25mm Length 26mm Washer Hd.

  • document

    www.mr2.com

    MR2 SC MK1 Tuning&fluids Questions... MR2 ERG hose Re: MR2 Valve Shims Re: MR2: UK Turbo owners ... BUT it is an automatic 8( > > It is for sale at 'Bob's Subaru' in Reading PA. > > Jeffrey Fazio > 13 ... Normally I would just go back and get > the right shims but in this case ...

  • document

    Contents

    For technical support call 619-661-6477 • Some products listed are not legal for sale or use on emission controlled motor vehicles ... Subaru EJ205 (WRX) & EJ25 (WRX STI) ... Shims . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 180

  • document

    ASSEMBLY INSTRUCTIONS - Scoobytuner.com

    ASSEMBLY INSTRUCTIONS FOR SUPERLITE 6 BIG BRAKE FRONT HAT KIT VENTED ROTOR TYPE 1999 - 2004 SUBARU IMPREZA WRX PART NUMBER GROUP 140-7005 WARNING: Some cleaners may stain or remove the finish on brake system components.

  • document

    BRAKE CATALOG - Autopartsource

    - All VGX Brake Kits Have Stainless Steel Metal Hardware Components ... ANTI-RATTLE SHIMS PAD SPRINGS KEY RETAINERS PAD SUPPORT SPRINGS NOISE SILENCER SHIM CALIPER GREASE* ... Sixteen Valve Engine 2WD ..... Two Wheel Drive 4WD ..... Four Wheel Drive Conversion ...

  • document

    BRAKE CATALOG - Autopartsource

    ANTI-RATTLE SHIMS PAD SPRINGS KEY RETAINERS PAD SUPPORT SPRINGS NOISE SILENCER SHIM CALIPER GREASE* ... Subaru..... 421 Subaru Truck ... Sixteen Valve Engine 2WD ..... Two Wheel Drive 4WD ..... Four Wheel Drive Conversion ...

  • document

    www.japanimports.fi

    Toyota (3SGTE/ 4AGE 16v/7MGTE) 6mm Exhaust Valve stem seal/ Viton. 13.2mm/.521" Subaru EJ20 / EJ25 Toyota (3SGTE/ 4AGE 16v/7MGTE) 6mm Intake Valve stem seal / Polyacr. ... Valve Lash Caps Cam Follower Shims 1 mm+ P4-MA84-N4 P4-MA84-P10 38.50mm(+1.5mm) BMIVN-1008

  • document

    Next Generation Quickie Proposal

    The Subaru 2.0L turbocharged, intercooled, H-4 found in the North American Subaru WRX Sedan and Wagon. I know many are going to say:-Too much power: but 227HP is at sea level, not 20,000. 227HP and 6000RPM would rarely be an engine output ...

  • document

    Next Generation Quickie Proposal - ImageEvent

    The Subaru 2.0L turbocharged, intercooled, H-4 found in the North American Subaru WRX Sedan and Wagon. ... Construction Belt Driven Camshafts with Automatic Cam Belt Tensioner Pentroof Combustion Chamber Solid Lifters with Valve Lash Shims EXHAUST SYSTEM Turbo Type FUEL SYSTEM MFI ...

  • document

    http www.rotaryforum.com forum printthread.php t=12802

    intercooled, VVTi(Variable Valve Timing), and drive by wire. EJ25T-STi DOHC: Available in 2004 in the WRX STi. ... Subaru Engine History from NASIOC Page 1 of 3 ... A turbo crossmember from a USDM WRXwill require shims

  • document

    www.japanimports.fi

    Valve Lash Caps Cam Follower Shims 1 mm+ P4-MA84-N4 P4-MA84-P10 SPR-M1005D ... VW / Subaru CF-35/2.8 35mm 91.60mm 90.95mm CF-35/3.3 CF-37/3.3 37mm 3.68mm ... Honda S2000 5.5mm Intake Valve Guide, Manganese Bronze ENGINE COMPONENTS INTAKE: VS-BM6-I CF-26/3.0 18mm 80 @ 38.6

  • document

    Kawasaki FR600V Engine - GXi Outdoor Power

    11 M10-001457 Switch relay, seat safety, Kawasaki FR-600 seat ... 48Z, tethered fuel cap, fuel valve 2 SP11-000105 Fuel system kit, Z, fuel supply line, fuel valve ... bolt, lockwasher, shims, use Loctite during assembly on bolt threads.. 18 SP11-000113 Hardware kit, Z, hydro output belt ...

  • document

    Operating Instructions Service Truck Air Compressors

    • Pilot valve control engine brand by Model: • CE7002 - Kohler® engine • CE7003 - Honda® engine • CE7004 - Subaru® engine Quick Reference reC oMMended il (2 ptionS) Single viscosity SAE 30 ISO100 nondetergent compressor oil.

  • document

    parts binder title pages - GXi Outdoor Power

    1 SP11-000062 Belt guard, 54ZB, set of 2 with rubber T-handle receivers 2 ... 36FB, 54FB, 100TB, Subaru EH65V, 22hp, with hardware and gaskets 4 SP12-000212 Hardware kit ... bolt, lockwasher, shims, use Loctite during assembly on bolt threads.. 18 SP11-000113 Hardware kit, Z, hydro ...

  • document

    W IMPORT AUTOMOTIVE - Web Camshafts

    CAM SUBARU IMPREZA DOHC (1998) 16v 2.5L.348/.370 224°/237° 204°/214° 517/222-607 Bolt in profile increases overall power. ... shims. Racing Valve Spring Kit Kit includes performance dual springs,Titanium retainers, HT steel collars, VC-Y30

  • document

    ohlins.tw

    Ohlins 08767-50 5,0 Cartridge kit Springs 5,5 08767-60 6,0 08415-60 08415-65 6,5 08416-55 ... Valve seat SE 15024-02 Shims 46/54/0.1 15025-01 15045-28 Shaft 16/255 15425-04 15489-02 ... Subaru BRZ / Toyota GT86 set 00163-20 Bump rubber 12.1/40/40

  • document

    Federal Mogul 675 Buyers Guide - ITACR.COM

    Gasket Sets- Valve Timing (260) . . . . . . . . . . . . . . . . . . . . . . .124 Gaskets - After Cooler ... Flange Shims (SLG) . . . . . . . . . . . . . . . . . . . . . . . . .219 Sleeves - Repair ... SUBAC Subaru Car SUBAT Subaru Truck SUPMP Superior Diesel Multi Purpose SUZUC Suzuki Car

  • document

    Ex c E E d i n g u s t o m E r s ’ Ex p E c tat i o n s ...

    Subaru, Suzuki. Check application guide from correct fluid. Coolant Red Concentrate. ... shims. Sold in original packaging with Beck Arnley label. Manufac-turers include Advics ... Valve Cover Gaskets Manifold Gaskets. Other Gaskets Available: Timing Cover. Thermostat

  • document

    Download - TECNO2

    16 valve solid inc. shims cf43 16 valve hydraulic cf55 306 gti 6 cf64 renault clio 16 valve solid inc. shims ... subaru ej2.0-ej2.5l hssu01 hssuz4701 toyota 4age 16 valve - mr2 12 point nuts hst4201 toyota 16v 2.0 3sgte hst4204 toyota supra 2jz hst4205 triumph gt6 (tr6 ok to 3.41" thickness)

  • document

    Respec Catalog 2005 - Hunt's Machine "We Rebuild Engines"

    Subaru 29 Suzuki 30 Toyota 4 cylinder 30 Toyota 6, V6, & V8 32 Volkswagon 33 Ford Heavy Duty 34 ... 28mm valve adjusting shims 7261C 7261 1992-12/96 Camry 92-96, Celica 92-99 & MR2 92-95, EXCEPT Calif emissions, 5SFE, DOHC 16v, w/o fuel rail cast in side of head,

  • document

    www.tecno2.com

    PEUGEOT 306 S16 VALVE (Steel Billet) PT2001 per pair PT2002 per pair PT2003 per pair ... SUBARU IMPEZA TURBO 5&6 SUB04 SUZUKI SZ2 SZ3 SZ5 SZ6 ... 16 VALVE SOLID inc. Shims CF43 16 VALVE HYDRAULIC CF55 306 GTi 6 CF64 RENAULT CLIO 16 VALVE SOLID inc. Shims

  • document

    High Performance 2006 Parts Pro Master Catalog

    2002-04 Subaru WRX 23-7701 2000-03 Toyota Celica GT-S ... Some parts are not legal for sale or use in California on any pollution controlled motor vehicle. 249 ... shims and three steel spacers that allow you to configure head gasket

  • document

    2003 LEGACY SERVICE MANUAL QUICK REFERENCE INDEX TRANSMISSION ...

    to provide SUBARU service personnel ... Select three or less shims from following table. (A) Drive pinion shaft (B) Roller bearing ... Control Valve Body.> 6) Turn over the transmission case to its original position. 7) Install pitching stopper bracket. Tightening torque:

  • document

    CLUB RACING BOARD - Racersites

    The fuel rail and fuel pressure valve are among the parts supplied by HPD in the FIT engine kit ... Subaru Impreza WRX STi ... camber adjustment may be achieved by the use of shims and/or eccentric bushings.

  • document

    Download

    ... brand new manual steering racks and power steering pumps are offered at competitive prices and cover ... guides, mechanic and hydraulic lifters and valve shims for ... NISSAN, HONDA, MITSUBISHI, MAZDA, SUBARU, YAMAHA and ISUZU. Moreover, we are a registered importer of all ...

  • document

    AST Suspension GRAND-AM Approved Parts List - 2011

    59AS-AS-A1-254 Subaru GD STI 5000 Left Front ... 16SV-A1-A1-100 Schrader Valve M8 16US-08-A1-008 Multi Seal M8 16US-04-A1-008 Multi Seal M4 ... Shims 16SH-17-A1-015 Shim 17 x 0,15 16SH-17-A1-030 Shim 17 x 0,30